| 適用范圍:茶餐廳設備,蛋糕房設備,面包房設備,咖啡店設備,飲品店設備<\/td> | 加工定制:是<\/td><\/tr><\/table>
本設備適用于鮮乳、果汁、飲料、棒冰及冰淇淋漿料、醬油、豆?jié){、煉乳、酒類等液體食料的瞬時滅菌，也可以用于流體藥料的滅菌，效果十分顯著。<\/span><\/span><\/p>三、主要技術性能和特點<\/span><\/span><\/p>主要技術性能：<\/span><\/span><\/p>1、 <\/span><\/span>處理能力<\/span> 1000L/h<\/span><\/p>2、 <\/span><\/span>滅菌溫度<\/span> 115~135<\/span>℃<\/span><\/span><\/p>3、 <\/span><\/span>使用蒸汽壓力<\/span> 0.78MPa(8Kgf/cm²)<\/span><\/p>4、 <\/span><\/span>高溫受熱時間<\/span> <\/span>≈<\/span>4-6S<\/span><\/p>5、 <\/span><\/span>出料溫度<\/span> <\/span>＜<\/span>65<\/span>℃<\/span><\/span><\/p>6、 <\/span><\/span>蒸汽消耗量<\/span> <\/span>≤<\/span>0.15Kg/L<\/span>物料<\/span><\/span><\/p>7、 <\/span><\/span>電機功率<\/span> 1.5KW<\/span><\/p>8、 <\/span><\/span>設備凈重<\/span> 395Kg<\/span><\/p>9、 <\/span><\/span>占地面積<\/span> 1m²<\/span><\/p>10、 <\/span><\/span>外形尺寸<\/span> 1200*920*1650mm<\/span><\/p>特點：<\/span><\/span><\/p>1、 <\/span><\/span>結構緊湊，占地面積小。<\/span><\/span><\/p>2、 <\/span><\/span>清洗方便，采用<\/span>CIP<\/span>化學洗滌劑，不需拆卸機件。<\/span><\/span><\/p>3、 <\/span><\/span>使用安全，操作方便。<\/span><\/span><\/p>四、原理及結構特點<\/span><\/span><\/p>超高溫瞬時滅菌機的原理如圖（<\/span>1<\/span>）所示。<\/span><\/span><\/p> <\/span>液料由進料泵（<\/span>2<\/span>）送入雙套盤管（<\/span>3<\/span>）內而得到預熱，然后通過高壓桶（<\/span>5<\/span>）由于桶內充滿蒸汽，管內液料很快被加熱，經保持三秒以上，液料中所含的細菌立即被殺死。此時，液料的溫度可從溫度表（<\/span>6<\/span>）中顯示出來。熱料出高溫桶后通過雙套盤管（<\/span>3<\/span>）與冷料熱交換獲得冷卻，因而出料溫度可顯著下降，一般情況低于<\/span>65<\/span>℃，如某些物料下一步工序需要供給較高的溫度，則可打開角式截止閥（<\/span>12<\/span>）補充加熱，如需繼續冷卻可接入冰水（<\/span>1~2<\/span>℃）出料是通過節流閥（<\/span>7<\/span>）進行的，這個閥能使物料維持在一定的壓力之下，使其沸點高于**加熱溫度，正常生產時將其進行調節，由泵之推力克服彈簧壓力產生的“背壓”控制流量，在洗滌時全部開啟，循環貯槽（<\/span>9<\/span>）可用來配制化學洗滌劑進行循環洗滌盤管壁面的積垢。<\/span><\/span><\/p>當處理高粘度物料時圖中<\/span>―<\/span>※可連接高壓均質機。此設備用戶自備，能力為<\/span>1.5~2KL/h<\/span>，壓力<\/span>14.7MPa<\/span>。<\/span><\/span><\/p>當需要提高處理能力時，可用兩臺離心泵，在圖中※處可連接中間泵，此泵和接管本廠可配套供應。<\/span><\/span><\/p>本設備與物料接觸部分，全部采用不銹鋼<\/span>1Cr18Ni9Ti<\/span>制造，雙套盤管用專用機床加工，同心度高，內表面光潔，從而使液料通過雙套盤管時引成均勻的液層，加熱十分均勻。<\/span><\/span><\/p>本設備的進料與出料均采用三通旋塞，流量可以根據需要調節，使用可靠。<\/span><\/span><\/p>設備特點：<\/span><\/span><\/p>1、 <\/span><\/span>連續生產、滅菌時間極短。<\/span><\/span><\/p>2、 <\/span><\/span>由于受熱時間短，可獲得優質產品。<\/span><\/span><\/p>3、 <\/span><\/span>由于采用超高溫滅菌，故滅菌效果特佳。<\/span><\/span><\/p>4、 <\/span><\/span>與離心泵或高壓均質機串聯使用，應用范圍廣，適宜于高粘度物料的滅菌。<\/span><\/span><\/p>5、 <\/span><\/span>由于設計上采用有冷熱料的熱交換器具有廢熱利用的經濟效果，故蒸汽消耗量小。<\/span><\/span><\/p>五、設備的安裝<\/span><\/span><\/p>1、 <\/span><\/span>本設備安置在車間內平整的地坪上，無需設備基礎。<\/span><\/span><\/p>2、 <\/span><\/span>設備安裝時可調節<\/span>4<\/span>只支腳螺栓，支腳必須與地坪接觸。進料泵<\/span>4<\/span>只腳同樣要求與地坪接觸，泵軸必須校正水平，以防設備使用時發生振動。<\/span><\/span><\/p>3、 <\/span><\/span>所有與本設備連接的管道都應注意不使設備受任何外力的作用，特別是應消除熱膨脹的影響。<\/span><\/span><\/p>4、 <\/span><\/span>進料泵必須保證電機轉動方向的正確性，操作者面對葉輪，泵軸應作逆時針轉動，安裝好后可用手轉動軸承是否靈活。<\/span><\/span><\/p>5、 <\/span><\/span>在蒸汽入口處，必須裝有<\/span>0.78MPa(8Kgf/cm2<\/sup>)<\/span>的安全閥。<\/span><\/span><\/p>6、 <\/span><\/span>當使用高壓均質機時，用戶自接管道應作<\/span>14.7MPa(150Kgf/cm2<\/sup>)<\/span>壓力試驗，不得滲漏。<\/span><\/span><\/p>7、 <\/span><\/span>循環貯槽放水豎管應與地溝接通，防止洗滌液腐蝕損壞車間地面，本設備安裝外形尺寸如圖<\/span>2<\/span>所示。<\/span><\/span><\/p>8、 <\/span><\/span>采用兩臺泵時的中間泵的安裝位置如圖<\/span>3<\/span>所示。<\/span><\/span><\/p>9、 <\/span><\/span>凡是發生突然停電的工廠，可在高溫桶下的<\/span><\/span>冷凝水出口管接上四通，一端接輸水閥，一端接進水截止閥后連接自來水管；一端接放水截止閥，接法見圖<\/span>4<\/span>。除隨機附件，其余管道件用戶自備。<\/span><\/span><\/p>聯系人:蘇俊 手機 15950156616 QQ:1760049025<\/span><\/p>地 址:上海市普陀區交通路4711號
電 話:021-36336635 傳真021-36336636
網 站 :www.jinbencn.com<\/span><\/p>
|
在線咨詢 
