|
?燃?xì)庹{(diào)壓箱及附屬設備的運行與維護<\/span><\/p>??現在簡單介紹一下燃?xì)庹{(diào)壓箱及附屬設備的運行與維護。<\/span><\/p>??燃?xì)庹{(diào)壓箱的巡查內容應包括調壓器,<\/span>過濾器,<\/span>安全切斷閥,<\/span>放散閥,<\/span>儀表閥門等設備的運行工況,<\/span>確保不存在泄漏等異常情況.<\/span><\/p>??燃?xì)庹{(diào)壓箱的運行與維護的基本要求:<\/span>清除各部位油污,<\/span>銹斑,<\/span>管路應通暢；檢查調壓器,<\/span>應無腐蝕和損傷；當發現問題時,<\/span>應及時處理；新投入運行和保養修理后的調壓器,<\/span>必須經過調試,<\/span>達到技術要求后方可投入運行使用,<\/span>停氣后重新啟用調壓器時應檢查進出口壓力及有關參數；燃?xì)庹{(diào)壓箱中的過濾器接口應定期進行嚴密性檢查,<\/span>前后壓差檢查,<\/span>排污及清洗.<\/span><\/p>??1. <\/span>調壓器的維護保養,<\/span><\/p>??1<\/span>） 每天巡視檢查一次,<\/span>檢查有無漏氣,<\/span>檢查調壓器工作是否平穩,<\/span>有無喘息,<\/span>壓力跳動及器件碰撞現象,<\/span>如有可能,<\/span>請及時排除故障,<\/span>否則應立即報告主管部門進行搶修.<\/span><\/p>??2<\/span>） 巡檢中按表格項目記錄調壓器工作參數,<\/span>包括進展壓力出站壓力,<\/span>有關運行情況,<\/span>故障情況,<\/span>及處理方法等.<\/span><\/p>??3<\/span>） 寒冷地區,<\/span>在采暖期前應檢查調壓室的采暖狀況,<\/span>或調壓器的保溫狀況.<\/span><\/p>??4<\/span>） 高中壓調壓站一般每季度保養維修一次,<\/span>中低壓調壓站每半年保養維修一次,<\/span>其方法如下,<\/span><\/p>???<\/span>清除各部位油污,<\/span>銹斑,<\/span>檢查針型閥是否通暢；<\/span><\/p>??2<\/span>檢查閥口有無腐蝕斑痕,<\/span>如發現問題,<\/span>應進行研磨或更換.<\/span><\/p>??3. <\/span>各部件涂潤滑油,<\/span>保障其活動自如<\/span><\/p>??4. <\/span>保養修理后,<\/span>須對調壓器認真調試,<\/span>達到技術標準后方可投入運行,<\/span>并安排值班人員觀察8h,<\/span>設備運行正常方可撤離.<\/span><\/p>??二過濾器的維護保養<\/span><\/p>??1<\/span>） 在日常運行和巡檢中,<\/span>應注意觀察記錄過濾器的前后壓差,<\/span>如壓差超過允許值時,<\/span>應及時進行檢修.<\/span><\/p>??2<\/span>） 巡視檢查中,<\/span>注意監聽有無水流聲音,<\/span>并做到定期或隨時排放內部積存的冷凝液.<\/span>排液應采用膠管引到室外的容器中,<\/span>用車運走,<\/span>集中處理.<\/span><\/p>??3<\/span>） 巡檢中,<\/span>注意檢查過濾器的各連接部位和焊口等處有無漏氣,<\/span>零部件有無損壞,<\/span>發現問題及時排除或報告主管部門.<\/span><\/p><\/div>
|
在線咨詢 
